Forklift Training Quiz

A detailed illustration of a forklift in operation, showing safety practices and correct loading methods in a warehouse setting, with a focus on proper posture and handling techniques.

Forklift Safety and Operation Quiz

Test your knowledge of forklift safety and operational practices with our comprehensive quiz. Whether you're a seasoned operator or just starting your training, this quiz is designed to reinforce critical safety guidelines and improve your operational skills.

12 engaging questions.
Multiple choice format for easy answering.
Improve your understanding of forklift mechanics, safety checks, and best practices.

12 Questions3 MinutesCreated by LiftingCup231

What happens to the center of gravity when you lift a heavy load

A. It moves from a low, central spot, to a high, forward spot.

B. It moves from a low, central spot to a lower spot in the back.

C. It moves straight up from the center of the forklift.

D. It moves from a high, forward spot to a low, central spot.

In what way are forklifts different from most automobiles?

A. Forklifts are much heavier.

B. Forklifts steer with the front wheels.

C. Forklifts have a tighter turning radius.

D. A & C.

Sophia is traveling with a load equal to the capacity of her forklift. The load is facing downhill, which is an unsafe practice. What do you think will happen if she raises the forks to eye level while driving down a ramp?

A. The forklift will be harder to steer.

B. The forklift will tip forward.

C. The forklift will tip to the right.

D. The center of gravity will shift to the rear.

Hector conducted a pre-use inspection and discovered a front tire with low air pressure and a crack across one fork. What problem could occur during his shift if they are not corrected?

A. Unexpected load shift and tipping

B. A broken mast resulting in damage to his cage

C. Reduced control of raising and lowering loads

D. All of the above

If you find something wrong with a forklift during an inspection, you should:

A. Use the forklift and report the problem at the end of your shift.

B. Make a temporary repair and report the problem at the end of your shift.

C. Have it fixed by authorized personnel before you operate the forklift.

D. Avoid using the affected part or mechanism.

Armin is heading toward an incline on a loaded forklift. What should he do?

A. Back up the incline.

B. Keep the load low and uphill of the forklift.

C. Find a different route to his destination.

D. Raise the load to see under it and drive up the incline.

If you’re stacking loads on top of each other, what must you make sure of before placing the load?

A. The top load is lighter than the bottom load

B. The stack is at least eight feet from any racks

C. The top of the stack does not block more than two light fixtures

D. There are additional supporting stacks nearby

Deandre needs to park the forklift for a couple minutes and go around the corner to pick up some paperwork. What should he do?

A. Set the parking brake and leave it running until he returns.

B. Put it in neutral and set the brake while it’s running.

C. Lower the forks and put it in neutral while he’s away.

D. Lower the forks, put it in neutral, set the brake, and shut off the power.

What step should you take before charging a battery?

A. Pour water into the acid.

B. Make sure you are the only person in the charging area.

C. Check to ensure the ventilation system is working properly.

D. Run a test to make sure current battery is below five percent.

Murissa just changed an LPG tank on her forklift. What can she do to test for leaks?

A. Hold a lighter at arm’s length and watch for a higher flame.

B. Smell and listen, or look for bubbles if using a soapy solution.

C. Park for fifteen minutes then weigh the cylinder to see if it’s lighter.

D. Wrap plastic around the connection and see if it balloons.

Forklift Training Quiz

Forklift Safety and Operation Quiz

More Quizzes